Product ID:B-185 HIGH TEMP VARNISH
MSDS Date:01/01/1985
FSC:8010
NIIN:00N000376
MSDS Number: BCFHQ

WESTINGHOUSE ELECTRIC CORP

INSULATING MATERIALS DIVISION PLANT
MANOR, PA 15665
US

Cage: 11927

WESTINGHOUSE ELECTRIC CORP

MANOR, PA 15665 US

Telephone: 412-864-8200

Cage: 11927

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 21.6%

OSHA PEL 100 PPM/150 STEL

ACGIH TLV: 100 PPM/150STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: 7.2%

OSHA PEL 100 PPM

NAPHTHA (PETROLEUM SPIRITS OR BENZIN)

CAS: 8030-30-6

RTECS: SE7555000

Fraction By Weight: 21.3%

OSHA PEL 100 PPM

Effects of Overexposure:EYES:IRRIT,RED,TEARS,BLUR VIS.
BRTHNG:NASAL,RESP IRRIT,DIZ,HDCH,UNCON,COMA. SKIN:IRRIT,DEFAT,DERM.

First Aid:EYES: FLUSH W/LG AMTS WATER. GET MD. SKIN: WASH W/SOAP &
WATER. REMOVE CONTAM CLOTHES, CLEAN BEFORE REUSE. INH: REMOVE TO
FRESH AIR, RESTORE BRTHNG IF NEC. GET MD. INGEST: DO NOT INDUCE
VOMIT, KEEP WA RM/QUIET, GET MD. POSS GI IRRIT, CHEM PNEUM.

Flash Point:66F
Lower Limits:0.7
Upper Limits:7.0
Extinguishing Media:DRY CHEM, REG FOAM, CO*2
Fire Fighting Procedures:SELF-CNTND BRTHNG APPAR W/FULL FACEIECE IN POS
PRESS MODE.
Unusual Fire/Explosion Hazard:VAPOR HEAVIER THAN AIR, MAY TRAVEL ALONG
GROUND. KEEP IGNITION SOURCES FROM HANLDING POINT.

Spill Release Procedures:SM SPILL: ABSORB LIQ ON PAPER, VERMICULATE,
FLOOR ABSORBENT OR OTHER ABSORBENT MATL & TRANSFER HOOD. LG SPILL:
ELIM ALL IGNIT SOURCES. STOP SPILL AT SOURCE, DIKE AREA TO PREVENT
SPREADING. PUMP LIQ TO SALVG TANK. USE ABSORBENT ON EXCSS LIQ.

Handling and Storage Precautions:CNTNRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CNTNRS RETAIN PROD RESIDUES, ALL HAZ
PRECAUTIONS ON SHEET MUST BE OBSRVD.
Other Precautions:OVEREXPOSURE TO PROD HAS APPARENTLY BEEN FOUND TO
CAUSE ANEMIA, LIVER, ABNORMALITIES, KIDNEY/EYE DAMAGE IN LAB
ANIMALS.

Respiratory Protection:NIOSH/MSHA APPRVD RESP IF TLV IS EXCEEDED
Ventilation:SUFFICIENT MECH, GEN &/OR LOCAL EXHST TO MAINTAIN BELOW TLV
Protective Gloves:BUNA-N
Eye Protection:CHEM SPLASH GOGGLES
Other Protective Equipment:WEAR IMPERVIOUS CLOTHING & BOOTS
Supplemental Safety and Health
VAP PRESS: 9.5. DOT: FLAMMABLE LIQ. SWALLOWING OF MATL CAN CAUSE GI
IRRIT, NAUSEA, VOMIT, DIARRHEA. ASPIR INTO LUNGS RESULTING IN CHEM
PNEUMONITIS, CAN BE FATAL.

Boiling Pt:B.P. Text:138C, 281F
Vapor Density:3.70
Spec Gravity:0.9360
Evaporation Rate & Reference:9.2, ETHER=1
Percent Volatiles by Volume:57.3

Stability Indicator/Materials to Avoid:YES
AVOID CNTCT W/STRONG OXIDIZING AGENTS

Waste Disposal Methods:SM SPILL: ALLOW VOLATILE PORTION TO EVAP IN
HOOD. ALLOW W/SUFFICIENT TIME FOR VAP TO CMPLTLY CLEAR HOOD DUCT
WORK. DESTROY REMAINDER BY BURNING IN IRON PAN. LG SPILL: INCIN.
PUT USED ABSORBENT MATL IN LANDFILL. FOLLOW FED, STATE, LOCAL
CODES.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.